The Herald, Sharon, Pa.

Local News

August 23, 2013

Industry spill contained

DEP: ‘Minimal’ impact on river

WHEATLAND — A sulfuric acid solution spilled from a tank at Wheatland Tube Co. early Thursday and flowed into a ditch that leads to the Shenango River.

Authorities said there were no injuries and that the spill was contained shortly after the sun came up.

Tim Feeney, general manager of Wheatland Tube, said a 20,000-gallon tank ruptured, spilling out a solution of 10 percent sulfuric acid and 90 percent water. The chemical is used to clean pipe before it is galvanized, he said.

The acid solution flowed south out of the Council Avenue plant in Wheatland and into a storm drain to a ditch that feeds a tributary of the river, according to the state Department of Environmental Protection.

DEP said it could not determine how much acid ended up in the ditch, but the agency reported seeing dead fish at the point where the tributary meets the river.

“It was surmised that the dead fish were from the tributary and washed into the Shenango River, and the spill had minimal impact on the Shenango River,” DEP said in a report Thursday.

Feeney said only 2,000 gallons of the solution left the company’s property.

He said his team immediately enacted its emergency recovery plans upon discovering the spill at 2:25 a.m.

“They started to put in dikes and dammed up the storm drain and the ditch to contain the fluid,” Feeney said.

“We plan for these types of events,” Feeney said. “We’re following our playbook.”

Vacuum trucks were brought in and sucked up spill materials for the biggest part of the work day and lime was applied for neutralization.

A DEP team arrived at the plant within an hour of the spill and left around 7 a.m., declaring the clean-up effort to be “ongoing, but under control.”

The county Emergency Management Agency and state Fish and Boat Commission also evaluated the site.

The commission said it would not comment on the spill because of the ongoing investigation.

The Shenango River Watchers is pleased with how the spill is being handled, said Jennifer Bararak, a founder and board member.

“We were told that the quality of the river was not affected,” Barbarak said. “We don’t believe there will be any residual damage.”

She said the River Watchers have worked closely with the DEP in the past and trust their ruling.

“It was contained very quickly – had it not been, it could’ve been a lot worse,” Barbarak said.

She said Wheatland Tube took immediate measures to make sure the river is kept clean.

Feeney said internal measures will also be taken to prevent this type of accident in the future.

“We want to determine what made the tank fail,” Feeney said, adding that improvements would then be made.

The DEP plans to follow up on the spill with a review of Wheatland Tube’s waste-handling and water-discharge procedures.

1
Text Only
Local News
  • Police: Kids in car were OK

    The mother of two young children was drunk and passed out when police found them all in a car parked along a city street, Sharon police said.

    July 29, 2014

  • To talk – or not – about police

    The mysterious agenda item, “No. 10,” at Farrell’s council meeting Monday became the center of a heated workshop and business session.

    July 29, 2014

  • Community thanks its first-responders

    Sharpsville honored its emergency responders Sunday at an event that included Mertz Towers residents as special guests.

    July 28, 2014

  • Drilling boom challenges state inspectors

    The state’s 83 well inspectors face a daunting enough challenge keeping tabs on 120,000 active oil and gas wells that have been drilled over the last century.

    July 28, 2014

  • Kidds Mill Covered Bridge A span of time

    Four generations of the Cadman family have enjoyed the Kidds Mill Covered Bridge, which is in Pymatuning Township near where the family’s ancestral farm is located.

    July 28, 2014 3 Photos

  • Intruder hurts woman, takes $5

    A home invasion in Hermitage Friday night sent an elderly woman to the hospital and netted the robber $5.

    July 27, 2014

  • national night out March against crime set for Aug. 5

    At the last Southwest Mercer County Regional Police Commission meeting, Chief Riley Smoot Jr. presented the number of incidents for each of the four communities in May.

    Farrell topped out at 819.

    July 27, 2014 1 Photo

  • high street trail Peaceful pathways

    History buffs and picnickers in the Shenango Valley won’t have to drive to Sharpsville to hang out at the old Erie Canal extension lock. They’ll soon have the option to walk or roll in on bicycles and even powered chairs to visit Canal Park near the outflow of Shenango Dam.

    July 27, 2014 1 Photo

  • balloonquest1 Balloon Quest celebrates 25 years

    Today is the final day of the 25th annual Western Pennsylvania Balloon Quest at Scotland Meadows Park.

    July 27, 2014 1 Photo

  • News briefs from July 26, 2014

    Man faces bomb threat charges

    June building tops $4 million in Hermitage

    July 26, 2014

  • Elderly man survives plane crash

    An elderly man survived wrecking his plane into a bank, then landing into a wetland, about 200 feet south of Runway 28 at Grove City Regional Airport in Springfield Township on Friday.

    July 26, 2014

  • Dontae Rashad Pinkins Man arrested for April gunfight

    Federal marshals and local police arrested Dontae Rashad Pinkins Thursday on a warrant accusing him of involvement in an April gunfight with another man in a Sharon alley.

    July 26, 2014 1 Photo

  • Hearing changed in starving case

    The time and place for the preliminary hearing of a Greenville mom accused of starving and beating her 7-year-old young son has been changed.

    July 26, 2014

  • Schell working on mural Drawn to Mexico

    Jason Schell probably is not exaggerating when he says that millions of people have seen his art.

    July 26, 2014 4 Photos

  • Farrell man, 24, arrested on warrant in connection with April shooting

    Federal marshals and local police arrested Dontae Rashad Pinkins Thursday on a warrant accusing him of involvement in an April shootout in Sharon.


    Pinkins, 24, of Farrell, is in Mercer County Jail after failing to post bond on gun charges.

    Additional details to follow.
     

    July 25, 2014